Efficiency of Raman Signal Enhancement by Ag and Au/Ag Nanoparticles Decorated on Aluminum Sheet SERS

Main Article Content

Nampueng Pangpaiboon
Kawinphob Phetnam
Sukon Kalasung
Chanunthorn Chananonnawathorn
Viyapol Patthanasettakul
Mati Horprathum
Pitak Eiamchai
Noppadon Nuntawong
Saksorn Limwichean*

Abstract

Surface Enhance Raman Spectroscopy (SERS) is a well-known technique used to analyze solutions of various substances that are at very low concentration levels. To create plasmonic resonance, many researchers have used Au nanoparticles decorated on SERS. Although Au nanoparticles offer high efficiency and high stability, they are expensive. An inexpensive noble metal with high numbers of free electrons, Ag nanoparticles has become an interesting alternative. However, Ag has a major drawback because it is easily oxidized. Therefore, this research aims to combine the good properties between Au and Ag nanoparticles for Raman signal enhancement. A low-cost laser marking technique was used to engrave aluminum surface. The Au/Ag nanoparticles were co-sputtered on the aluminum template with decorating times ranging from 30-360 s. FE-SEM was used to characterize the nanostructure of the nanoparticles on SERS. Hydrophobic properties of the SERS surface were identified by contact angle measurement. A Raman spectrometer was used to measure the intensity of the enhanced Raman signal. From the results, the decorating time that provided the highest contact angle and highest Raman intensity enhancement was 270 s for both Ag and Au/Ag nanoparticles. The limit of detection of Ag and Au/Ag aluminum SERS was 10-8 M for Rhodamine-6 G. The enhancement factor for Ag aluminum SERS was slightly greater than that for Au/Ag aluminum SERS, as expected. After 60 days of shelf-life testing, Ag aluminum SERS presented the highest Raman enhancement. However, the Raman signal from Ag aluminum SERS dramatically decreased, afterwards. On the other hand, Au/Ag aluminum SERS showed a constant ability to enhance the Raman signal for as long as 150 days.


Keywords: Raman scattering; laser-engrave; Au/Ag nanoparticle SERS; 3D hybrid SERS; sputtering


*Corresponding author: Tel.: (+66) 830187227


                                            E-mail: [email protected]

Article Details

Section
Original Research Articles

References

Mou M, Chen, D., Wang, X., Zhang B., He, T., Xin, H. and Liu, F.-C., 1991. SERS and UV spectra of meso-tetrakis (4-sulfonatophenyl)-porphine adsorbed on Ag2O colloids. Chemical Physics Letters, 179(3), 237-242.

Cyrankiewicz, M., Wybranowski, T. and Kruszewski, S., 2007. Study of SERS efficiency of metallic colloidal systems. Journal of Physics, 79, https://doi.org/10.1088/1742-6596/79/1/ 012013.

Kavitha, C., Bramhaiah, K., John, N.S. and Ramachandran, B.E., 2015. Low cost, ultra-thin films of reduced graphene oxide–Ag nanoparticle hybrids as SERS based excellent dye sensors. Chemical Physics Letters, 629, 81-86.

Weng, G., Yang, Y., Zhao, J., Li, J., Zhu, J. and Zhao, J., 2020. Improving the SERS enhancement and reproducibility of inkjet-printed Au NP paper substrates by second growth of Ag nanoparticles. Materials Chemistry and Physics, 253, https://doi.org/10.1016/j. matchemphys.2020.123416.

Li, R., Lei, J., Zhou, Y. and Li, H., 2020. Hybrid 3D SERS substrate for Raman spectroscopy. Chemical Physics Letters, 754, https://doi.org/10.1016/j.cplett.2020.137733.

Pal, A.K., Pagal, S., Prashanth, K., Chandra, G.K., Umapathy, S. and Mohan, B.D., 2019. Ag/ZnO/Au 3D hybrid structured reusable SERS substrate as highly sensitive platform for DNA detection. Sensors and Actuators B: Chemical, 279, 157-169.

Zhao, X.Y., Wang, G. and Hong, M., 2018. Hybrid structures of Fe3O4 and Ag nanoparticles on Si nanopillar arrays substrate for SERS applications. Materials Chemistry and Physics, 214, 377-382.

Qiu, H., Wang, M., Li, L., Li, J., Yang, Z. and Cao, M., 2018. Hierarchical MoS2-microspheres decorated with 3D AuNPs arrays for high-efficiency SERS sensing. Sensors and Actuators B: Chemical, 255, 1407-1414.

Botta, R., Eiamchai, P., Horprathum, P., Limwichean, S., Chananonnawathorn, C., Patthanasettakul, V., Maezono, R., Jomphoak, A. and Nuntawong, N., 2020. 3D structured laser engraves decorated with gold nanoparticle SERS chips for paraquat herbicide detection in environments. Sensors and Actuators B: Chemical, 304, https://doi.org/10.1016/j.snb. 2019.127327.

Kim, Y.-T., Schilling, J., Schweizer, S.L. and Wehrspohn, R.B., 2017. High density Ag nanobranches decorated with sputtered Au nanoparticles for surface-enhanced Raman spectroscopy. Applied Surface Science, 410(C), 525-529.

Nuntawong, N., Horprathum, M., Eiamchai, P., Wong-ek, K., Patthanasettakul, V. and Chindaudom, P., 2010. Surface-enhanced Raman scattering substrate of silver nanoparticles depositing on AAO template fabricated by magnetron sputtering. Vacuum, 84(12), 1415-1418.

Tang, H., Meng, G., Huang, Q., Zhang, Z., Huang, Z. and Zhu, C., 2011. Array of cone shaped ZnO nanorods decorated with Ag nanoparticles as 3D surface-enhanced Raman scattering substrate for rapid detection of trace poly-chlorinated biphenyls. Advanced Functional Materials, 22(1), 218-224.

Xue, L., Yan, B., Li, Y., Tan, Y., Luo, X. and Wang, M., 2018. Surface-enhanced Raman spectroscopy of blood serum based on gold nanoparticles for tumor stages detection and histologic grades classification of oral squamous cell carcinoma. International Journal of Nanomedicine, 13, 4977-4986.

Lu, G., Li, H., Liusman, C., Yin, Z., Wu, S. and Zhang, H., 2011. Surface enhanced Raman scattering of Ag or Au nanoparticle-decorated reduced graphene oxide for detection of aromatic molecules. Chemical Science, 2(9), 1817-1821.

Moram, S.S.B., Byram, C., Shibu, S.N., Chilukamarri, B.M. and Som, V.R., 2018. Ag/Au nanoparticle-loaded paper-based versatile surface- enhanced Raman spectroscopy substrates for multiple explosives detection. ACS Omega, 3, 8190-8201.

Xu, F., Xuan, M., Ben, Z., Shang, W., and Ma, G., 2021. Surface enhanced Raman scattering analysis with filter-based enhancement substrates: A mini review. Reviews in Analytical Chemistry, 40, 75-92.

Ju, J., Liu, W., Perlaki, C., Chen, K., Feng, C., and Liu, Q., 2017. Sustained and cost effective silver substrate for surface enhanced Raman spectroscopy based biosensing. Scientific Reports, 7, 6917, https://doi.org/10.1038/s41598-017-07186-9.

Eiamchai, P., Chananonnawathorn, C., Horprathum, M., Patthanasettakul, V., Limwichean, S. and Nuntawong, N., 2020. Spatial elemental investigations in nanostructured alloyed Ag/Au SERS substrates by magnetron sputtering oblique-angle co-deposition towards increased performance and shelf life. Applied Surface Science, 513, https://doi.org/10.1016/j.apsusc. 2020.145748.

Ruan, S., Li, X. and Jiang, T., 2020. Hydrophilic-hydrophobic poly(dimethyl siloxane)-based SERS substrate with internal Raman signaling. Materials Chemistry and Physics, 255, https://doi.org/10.1016/j.matchemphys.2020.123582.

Sakir, M., Yilmaz, E. and Onses, M.S., 2020. SERS-active hydrophobic substrates fabricated by surface growth of Cu nanostructures. Microchemical Journal, 154, https://doi.org/10.1016/ j.microc.2020.104628.

Li, Z., Zhu, K., Zhao, Q. and Meng, A., 2016. The enhanced SERS effect of Ag/ZnO nanoparticles through surface hydrophobic modification. Applied Surface Science, 377, 23-29.

Lv, K., Si, H., Liu, j., Zhu, T., Xia, Y., Chen, S., Zhao, Y. and Yang, C., 2020. Plasmonic filters based on MoS2@Au/Ag hybrids: Controllable separation, preconcentration, and sensitive SERS detection. Journal of Alloys and Compounds, 846, https://doi.org/10.1016/j. jallcom.2020.156438.

He, S., Chua, J., Tan, E.K.M. and Kah, J.C.Y., 2017. Optimizing the SERS enhancement of a facile gold nanostar immobilized paper-based SERS substrate. RSC Advances, 7(27), 16264-16272.

Kundu, S., Dai, W., Chen, Y., Ma, L., Yue, Y., Sinyukov, A.M. and Liang, H., 2017. Shape-selective catalysis and surface enhanced Raman scattering studies using Ag nanocubes, nanospheres and aggregated anisotropic nanostructures. Journal of Colloid and Interface Science, 498, 248-262.

Wu, L., Zhang, W., Liu, C., Foda, M.F. and Zhu, Y., 2020. Strawberry-like SiO2/Ag nanocomposites immersed filter paper as SERS substrate for acrylamide detection. Food Chemistry, 328, https://doi.org/10.1016/j.foodchem.2020.127106.

Li, Q., Gong, S., Zhang, H., Huang, F., Zhang, L. and Li, S., 2019. Tailored necklace-like Ag@ZIF-8 core/shell heterostructure nanowires for high-performance plasmonic SERS detection. Chemical Engineering Journal, 371, 26-33.